Cargo Conversion - Electrical Part 2
HTML-код
- Опубликовано: 4 фев 2025
- SOLD!
Thank you for support! Here are Amazon links to Items I used in the build:
Xantrex ProWatt Pure Sine: goo.gl/9TJ5Tx [Affiliate]
Converter Progressive Dynamics: goo.gl/FrKcae [Affiliate]
MPPT Charge Controller: goo.gl/gtikMw [Affiliate]
Suaoki 100w Solar Panel: goo.gl/hhWys6 [Affiliate]
Blue Sea Fuse box: goo.gl/cCgSxu [Affiliate]
DC Disconnect Switch: goo.gl/MmPTsx [Affiliate]
King Jack Powered Antenna: goo.gl/tZdBwQ [Affiliate]
All that's left is to add a smart battery shunt in the DC Neg cable where it comes out of that battery box and you will have the Fuel gauge for the batteries! Awesome tool to help keep the batteries topped off.
instead of changing the plug over you could get what's called an automatic transfer switch, its normally used to switch between generator and shore power, but small ones exist that would work perfectly for your setup.
Really appreciated your detailed and easy to understand explanation of your electrical system. Thanks for sharing 👍👍👍
I like how you used the yellow ext. cord wire for the runs, looks clean.
Thanks. I’ll save this for reference. Great explanations.
Thanks for the video! Just starting to plan my own build and this is very helpful.
Great video Sir, Very nice system you got there, I learned a lot, Thank you for sharing.
top notch!
very similar to what I have in mind.
thanks for taking the time to film these.
plumbing & gas systems are next right? ;)
keep em coming!
Real, real nice job there my man!
Hi,
Nice setup by the way. Probably the best explaination video I have seen yet and I have looked at quite a few.
Was wonder how you wired the solar into it. I see you show the wires from the solar panels in to the converter but from there where?
Thanks,
Scott
Just the Video I was looking for. Great job. Do they make a Converter-Inverter combo?
I have looked everywhere for this info. Thank you so very much for this video. I also have flex panels on a cargo trailer with ac and dc also. I am going to be a full time nomad in my 14 ft cargo trailer. 7 high and 7 wide cargo camper. I knew the parts but did not know how to connect all together. Have you considered a transfer switch rather than plugging and unplugging the convertor?
Have question I don’t know if you can answer, I like your set up but, my question is that I’ve been watching other set ups and they have a surge guard right after the wire that come in from the shore power do you know why ? Why don’t you have one? What’s a surge guard ? Thanks
You did a fine job with that trailer. The best one I’ve seen so for. Have you ever thought about making money building those for other people?
Good stuff! Thanks for sharing.
I know it's been a while - but what is that right below the solar charge controller and then how does that hook into the system? Does the cables from the controller go to the bus bar? Or into the Converter, or straight to the batteries? Top notch job on this system and thanks for sharing -
Thanks for the video. Did you use extension cords for the DC wiring?
Where is the ground on your trailer?
Did you used romex cable for your outlets?
Good job !
I'd be curious to see you water set up. I didn't see a resivior to pump from if boondocking.
I am converting an enclosed trailer to a camper conversion. I think you explained the DC, batteries, and converter pretty good to where I think I understand, and I think I got it. Just a quick clarification question. Do I connect the battery and the converter (also a battery charger) to the same positive fuse block and same negative ground block? If I'm plugged into shore power the converter supplies the power to the 12 volt fuse block, and charge batteries? And when I'm disconnected from shore power then the batteries supply power to the fuse box? So both are connected at the same time?
Thank you in advance.
Robert
Nicely done! I'm assuming there are 120v appliances that are powered by shore power when you're plugged in, and then powered by the inverter fed from the batteries when you're not plugged into shore power. But how do you make sure that the inverter AND shore power don't BOTH feed your 120v appliances and outlets when you plug into shore power? Do you have an automatic transfer switch of some kind, or do you do this manually?
Hey - Love the setup and how you demonstrate the entire thing in a way that's easy to understand. My question: Is the power converter not GFI protected, since it is not downstream from the outside GFI outlet? Thanks again for these incredibly helpful videos. You are a fantastic teacher!
Fantastic
Where can I get one like this?
Thanks again for part 2. I would really like to know how much money 💰 I’m going to need for this build. Do you think you could do a cost break down? I’m still trying to save the $8000 for the trailer I want.
WhiteOak 26 take your time, like I said. I’m still working on that $8k for the trailer.
Thank you 🙏🏼
Can you please clarify the ground?
send me a list on your battery set up converder and inverder
Great video and systematic planning. Does your converter/charger wire to the positive bus or the battery directly or the DC distribution box?
WhiteOak 26 Great thanks! One more quick question, could you have substituted a 300a circuit breaker for the 300a fuse and on/off switch coming from the house battery to the positive bus? Seems like that would work as a switch and a fuse?
WhiteOak 26 Thanks so much for your hard work and all your input
Another couple questions for you, did you wire the ground to the neutral bus? Also your converter is a 60 amp, why doesn't that trip your breaker?
WhiteOak 26 hey whiteoak I'm finally starting this project, one quick clarification. On the 120 breaker box how did you deal with the ground? Did you tie it into the neutral bus and did that tie to any other ground (I assume not the frame?!?) Thanks for your help
Mr. White Oak 26. Hi. I had some electrical questions I would love to run by you for just a short time on the phone. Any chance of a phone call or I could call you? Thanks Johann
Do you have a ground wire coming off of the ground bus into the fuse block?
Awesome!! Thanks for the reply!!
I'm deaf now thanks to that crap opening...thanks for that.
Nice videos. But please get a more appropriate opening music. I cant stand it. :)