mini AC clutch part 1
HTML-код
- Опубликовано: 29 сен 2024
- Take a look at my ebike channel
/ @magicebikestuff890
Diagnosis and cheap repair of 2003 Mini Cooper AC compressor clutch.
Buy this part on my website in mini cooper parts section at www.kansascitytdi.com
If you would like to donate to the continued production of these videos find the donate icon on my website at www.kansascitytdi.com
Please do not call me for tech help. Please post your questions in the comments below..
Great explanation of why a circuit must be under a load in order to create a voltage drop. A bad ground tested under no load will often appear to be a good connection (no voltage drop). A little bit of knowledge regarding Ohm's law will help in this. Given a fixed resistance, in this case the wire going to ground along with the grounding connection, the more current flow, the higher the voltage drop. Voltage drop measured = Amps x Resistance.
Nice explanation.
Good job bro ❤
thanks
I saw another vid- 2003 Honda- he put a little pressure on the clutch and it started operating. A little too much gap for the magnet to pull. Took off a shim, to lessen the out of spec wide gap, and it operated normally.
Eric O? (SMA?) I seen similar videos but remember this car had OPEN circuit on the clutch coil (magnet).
Sma one was a taurus. ruclips.net/video/AfHmgM-GRo4/видео.html
The coil is a $90 part and it’s worth trying to replace that first. Also you may not need to pull the front end off of the car.
ruclips.net/video/d1A41iHzBiE/видео.htmlsi=I3Ab6rqRNRa-DEDH
A tad confusing since I’m wondering now if my AC clutch is bad or the entire compressor is bad instead in my 2005 Mini R52 1.6L? 🥵
I'm in the same situation with my 2005 R50, but I am replacing my clutch first because it's relatively inexpensive, whereas doing the whole compressor is a more expensive and involved job. The compressors on our car are pretty bulletproof, so I'm optimistic that the compressor is still good. Good luck!
When attempting to do any kind of work, I always do my research first especially if it is a new task. Research can make or break what you are about to do. Nice relay testing kit.
Absolutely!
On a normal relay the 5th prong is for a circuit where you need power through the relay when it is not energized. Mini relays can be different, in fact some of the prongs are in different locations compared to a normal relay.
Did I not say that? Thanks for adding that.
I hate mini for this anything on the distrubution system i have to disassemble the all front of the car...
Older ones like this come apart easy
Will the a/c clutch spin if there’s no freon?
No. Control system will see low pressure and wont turn on the compressor.
Where can I get does diagram
mechanics use one of 3 services to get wiring diagrams. Pro-demand (Mitchell), Identifix or All-Data. They each have their benefits and drawbacks. A DIY'er should consider buying a hard copy repair manual that has schematics in it for his car.
Do you have the clutch part for 2009 mini copper s? Thanks
Yes I do. kansascitytdi.com/mini-cooper-parts/
@@CoolAirVw Thanks!
thanks
Welcome. Thanks for your continued viewership and commenting on my channel. I notice that Dan Man watches and comments.