Thanks a lot. My trimmer stopped working suddenly. I followed your instructions and noted that the insulation of one of the connection cables was damaged and caused a short circuit with the body of the battery. Just fixed that and the trimmer is working now. Thanks again !
Thanks for making this video very thankful to you. You saved my 1000 rs. Since last year my shaver was dead after seeing your video I repaired it myself. Great thanks to you saving my 1000 rs.
Thank you brother. This is very help full video From Very long time my trimmer is getting fast draining problem today I saw how battery is arrange and how to open thanks again
My philips hc5450 trimmer is charging but cannot start. I have checked the motor with an external battery and it's working. The inbuilt battery is also working, checked the buttons and it looks fine. I think the problem is with the board. Can we buy the circuit boards. Or can it be fixed otherwise ?
I want to ask one thing HOW THIS WORKS ON DIRECT FROM THE CHARGER AND ALSO FROM THE BATTERY? Beacause as we slide the button the positive of the battery sswitches from motor to supply but how come the motors works ? Then when direct from charge?
V nice video sir... I want to chance the circuit by removing the battery.. want to do it directly .. can i chance the wiring and give direct power to the motor.. The trimmer dies not work while charging
No it wont. AC to DC conversion is taking place at the plug and the device has no bypass charging. Instead cut a permanent hole at the back and make it battery-swappable. Philips uses very low quality rechargeable battery and you would be better off buying an eneloop or duracell high performance rechargeable AA battery. Another very DIY level option is to replace the power slot with USB-C by using a CCCV circuit. No more need to carry propriety pin AC adapters
Hi i'm from Argentina. I have the same Phillips Trimmer but i lost a part. The plate one you take in the minute 1:00 in the video with the gripper. And i don't know how to get it back. I'm looking for some manual disassembly, or someone who sells the trimmer in bad use. I just need that part, mine trimmer is almost new. If you have any idea, it works for me. Thanks for the video, sorry for my poor english. Cheers.
My trimmer motor is rotating without the head, but when head is attached, motor is getting stuck and shorting the supply. Tried oiling the head but no use. Any suggestions?
Sir, what kind of 100E Resistor is this???? Is it simple 100E resistor??? Is there any tolerance rate 5% or 10%???? What does that 2 stripes on Resistors indicates???
Sir meri elekta ki trimmer Short ckt ho gayi h uski moter 2.1 volt ki h. Direct DC charger se chlane per load nahi leti h . uska koi upaay h kya .wo repair ho skti h kya.please reply me sir
भाई आपने जो 57 sec पर मोटर से निकाला है, और जो ब्लेड को move करता है, उसका क्या नाम है, क्या वह मिल सकता है market में। मेरा खो गया है। कृपया जवाब दीजिये ।😢😢😢
Can you add same video for new model on battery replacement. In new model power cell are on pcb mounted and no video available for replacement of same.
Excellent educational video. Sir, in my trimmer the small metal part between the blade and motor comes out of its socket whilst the trimmer is in operation and the trimmer stops. When I remove the blade that small part falls off. What is the solution please?
syska trimmer company. when remove the blade motor will rotating and blade is fixed motor not rotating and blade is not moving. so please show the reasons and solution
I Philips QT4005/15 trimmer. But I am facing a another problem. My trimmer motor moving properly without attaching blade. When I attaching the blade its not moving. Can you help me to solve it???
I changed the battery and now the weight that moves the blade loses traction with the motor. Motor shaft is spinning inside the hole in the weight, and the weight doesnt move. What can be done about it? UPD its probably not the best idea, but i followed advice from the comments and superglued the rotor to the motor shaft. Works fine. Just be ready to turn off the trimmer if the blade is stopped by thick hair or something, otherwise the motor can be damaged.
Hi sir. I have this kind of trimmer. I can use it, when it fully charged 100%. Let’s say I used it for 5mins and the battery still have 80% remaining at that moment. If I’m no longer use it, it will automatically drained to 0%. So everytime I want to use it, i have to charge all over again. What is the problem?
Bro ,i have changed the battery ,put infinite 1.2 v 1050 mah .but now trimmers seems drop in power or rpm drop .what a reason ,i also charged for 7 hrs
@@ashokatech sir... Meraaa Trimmer ka motor move kar raha hai... bt jab blade se laga ta hu to motor didn't work what should I do???? Aur yadi mujhe motor change karna hai to uska Serial no or anything ????
Thanks a lot.
My trimmer stopped working suddenly. I followed your instructions and noted that the insulation of one of the connection cables was damaged and caused a short circuit with the body of the battery.
Just fixed that and the trimmer is working now.
Thanks again !
Most welcome sir..
@@ashokatech
Is have Philips QT 4011, is the same procedure for opening of QT4011, not sure if the Battery is same or different ?
@@Royd20 4011 has 2xaaa battery ,and it is more complicated because of pcb
@@ashokatech Hello sir ,when i connect blade cap to trimmer then motor works but blade doesn't move.please help to solve this.
आपने पक्कड से जो पार्ट निकाल उसका नाम क्या है
Thanks for sharing by looking at your video I have repaired my trimmer. Now it's working fine.
Thanks for making this video very thankful to you.
You saved my 1000 rs.
Since last year my shaver was dead after seeing your video I repaired it myself.
Great thanks to you saving my 1000 rs.
What component you changed, brother???
Thank you brother. This is very help full video
From Very long time my trimmer is getting fast draining problem today I saw how battery is arrange and how to open thanks again
Your most welcome Vipul ji 🙂
Awesome video. That circuit digram you draw was very good.
thankyou very much brother, from your tips i repaired my trimmer.
Your most welcome Preetam ji 🙂
Thank u so much sir ,ur video helped me alot
Very good information about trimmer circuit ❤❤❤❤❤
Many many thanks
👍 Thank you it helped to get that Phillips Trimmer fixed
Your most welcome Sunil ji 🙂
Thank you sir, this video is really helpful. 👍😊
Bohot hi jaruri video hai mere liye, thank you so much 👌👌
Nc video sir... it is very helpful for all of us!
Thank you so much sir 🙂
Thank you bro .....by your video reference I fixed my trimmer.....
Your most welcome dear 🙂
Wow... This was helpful... Thank you :)
शुक्रिया, आपके इस विडियो से हमने trimmer खोलना सीखे, जो कि trimmer बनाने में काफी मदद किया
Awesome, Very well explanation speacially the diagram.
Thank you so much sir 🙂
This is very useful video for you , please watch full video, ruclips.net/video/QstKrxnwtz4/видео.html
थैंक यू सर आपके वीडियो की वजह से मैं अपना मशीन खुद ही ठीक कर लूंगा बहुत-बहुत धन्यवाद
awsome Sir...and thank-you
Thank you sir
The cam which rotates the balde
Where can I get that part...
My philips hc5450 trimmer is charging but cannot start. I have checked the motor with an external battery and it's working. The inbuilt battery is also working, checked the buttons and it looks fine. I think the problem is with the board. Can we buy the circuit boards. Or can it be fixed otherwise ?
Sir, can we somehow make it run using samsung 5v 0.7a charger with resistors (corded)
Thnks bro, by ur vdo i made my trimmer,
Most welcome sir
very usefull and detailed video bro,thank you.
I want to ask one thing HOW THIS WORKS ON DIRECT FROM THE CHARGER AND ALSO FROM THE BATTERY? Beacause as we slide the button the positive of the battery sswitches from motor to supply but how come the motors works ? Then when direct from charge?
Very good video
Thanks for the video
Thank you Girish bhai ji
Thanks for tutorial.
Welcome
Bro, Nice video. And where can I purchase that motor shaft Cam?. (0.53 minute part removed).
GLUE THE METAL ROTATOR ONTO THE SPINDLE If your motor works but the cutting blades do not move
I also did it
My motor moves but blades are not cutting and moving...can you please describe the solution elaborately...like what is spindal?
@@Anujsyal595 same problem mine... do you get any solutions
@@RishoveJana yes I have fixed my self....I just put a thread piece through rotor hole and passed it through of that little small hole
@@Anujsyal595 ohooo that is good
If you can help me when I plugged in charger in my trimmer red light blinks but it doesn't charge why?
Same problem bro
Is there anyway we make it corded and cordless both??
Nice explanation.
Jayaram
V nice video sir... I want to chance the circuit by removing the battery.. want to do it directly .. can i chance the wiring and give direct power to the motor.. The trimmer dies not work while charging
😮ஸ்ரீGOOD.your.philips.trimer.circuit&service.very.simple.l.was.understand..THANKS.SIR..NEXT..TIRIMER. **KUBRA.4❤
can we concert this port to mobile charging by mobile charger.
That means i can use it while charging ?
Thanks trimmer is working now
Hi, Is it possible to remove the battery and use it only from the mains? if you connect the positive contact from the battery to the switch?
Bhai mila koi jawaab iska?????
No it wont. AC to DC conversion is taking place at the plug and the device has no bypass charging. Instead cut a permanent hole at the back and make it battery-swappable. Philips uses very low quality rechargeable battery and you would be better off buying an eneloop or duracell high performance rechargeable AA battery. Another very DIY level option is to replace the power slot with USB-C by using a CCCV circuit. No more need to carry propriety pin AC adapters
@@HolyRamanRajya Ok
Hi I lost that small metal connector between motor and blade attachment.where I can get that spare in Hyderabad
Pro Tip: Don't clean your trimmer over the sink. You may lose parts down the drain-like I did.
Sir..Could you plz share a video to increase the heating system of wax heater..
Hi i'm from Argentina. I have the same Phillips Trimmer but i lost a part. The plate one you take in the minute 1:00 in the video with the gripper. And i don't know how to get it back. I'm looking for some manual disassembly, or someone who sells the trimmer in bad use. I just need that part, mine trimmer is almost new. If you have any idea, it works for me. Thanks for the video, sorry for my poor english. Cheers.
Plese send me a pic that part.
For direct chat follow me on instagram..
instagram.com/ashoka.tech
@@ashokatech I just found a place where they can repair the machine for me for a
reasonable price. Thanks so much for the attention, cheers !
@@ashokatech i lost it too, and have written to you on Instagram, but no respond..
Thank you very much. appreciated
Most welcome sir ♥️
Can we bypass batery, directly connect from charging starting point to motor. Will it work?
0:53 wo part ko kya bolte hai....
Aur wo kaha milega ?
Bhai great video really helpfull
Pata chala wo part ko kya bolte h? Online milta h kya? Mera bi wohi parta kho gya h.
Where did I get pcb board for this modal trimmer and battery also
Is that possible to change charging jack?
My trimmer motor is rotating without the head, but when head is attached, motor is getting stuck and shorting the supply. Tried oiling the head but no use. Any suggestions?
Sir, what kind of 100E Resistor is this???? Is it simple 100E resistor??? Is there any tolerance rate 5% or 10%????
What does that 2 stripes on Resistors indicates???
Hello to use it connected directly from the source, without battery. What should I do? I would have to cancel the battery and that's it?
Sir meri elekta ki trimmer Short ckt ho gayi h uski moter 2.1 volt ki h. Direct DC charger se chlane per load nahi leti h . uska koi upaay h kya .wo repair ho skti h kya.please reply me sir
Hello sir....muje iske part mil sakte h kya jo bled wale portion k bad round ghumne k liye jo chota sa gol wo chahiye
Bro Vega men trimmer ma same Aisa hi open hoga kya...???
My trimmer not getting charged can i connect to direct supply insted of battery??
Ashok sir plz tell me the spinner who moves the blade if it will become free so what I have to do😅
How to glue the rotor to the shaft ?
Bro i think the diode in my trimmer is not working can i replace it.
Sir jo cutter hota h vo mera khrab ho gya h kya sirf cutter market me milta h online please link de de ya kya search kru wo bta de
Sir I have philips trimmer with 450 Mah battery .can I use in that 750 mah ya 1100 mah AAA battery .
Thank you so much
Your welcome sir 🙂
Very useful video. I lost my charger can you suggest any alternative?
Use Nokia phone charger to connect the trimeer
battery replace karna tha aapne bata diya dhanyawaad
Actually i broke the plastic part where blade gets locked ,any fix or replacement parts for that?
Send me a pic that part on my Instagram.
For direct chat follow me on instagram..
instagram.com/ashoka.tech
I lost the rotor.the little piece you take out with the pliers
भाई आपने जो 57 sec पर मोटर से निकाला है, और जो ब्लेड को move करता है, उसका क्या नाम है, क्या वह मिल सकता है market में। मेरा खो गया है। कृपया जवाब दीजिये ।😢😢😢
Can you add same video for new model on battery replacement. In new model power cell are on pcb mounted and no video available for replacement of same.
Ofcourse sir 👍
thanks for details
Wellcome sir
Excellent educational video.
Sir, in my trimmer the small metal part between the blade and motor comes out of its socket whilst the trimmer is in operation and the trimmer stops. When I remove the blade that small part falls off.
What is the solution please?
Have you found a solution for the rotor falling out from the trimmer problem?
Nicely drawing circuit
Thank you so much Subhankar ji 🙂
ruclips.net/video/QstKrxnwtz4/видео.html
Thanks brathor
Great video ❤❤❤❤
How to convert it to DC current directly without battery?
Can the charger be used for DC?
I think yes, just power the motor with some external adapter.
Do you know any one Repairer Mumbai. Please advise as I am unable to fix spring Of blade. Thanks
Is the diode same for qt4001
Nice details ..
Thank you so much Nilesh ji.
Please visit my website www.ashokaonline.com
syska trimmer company. when remove the blade motor will rotating and blade is fixed motor not rotating and blade is not moving. so please show the reasons and solution
Helpful video...
I think my trimmer motherboard is short, are trimmer motherboard available in market?
Hello sir namaste, sir moter me jo fiter ke uper lga hota hai uska kya naam hai
I love you Bhai. Keep updating your knowledge with us 😘
Mere trimmer pe 1.2v 450mah ka battery hain isko change karke 450mah ke jagah pe 1000 ya 750 mah lagaya to yeh chalega ki nahi?
Bhai mera trimmer ka on off switch ke neeche wala steel ka blade toot gaya h kya mil sakta ya new buy karu
Thanks Bro.
Most welcome Amit Bhai 🙂
I Philips QT4005/15 trimmer. But I am facing a another problem. My trimmer motor moving properly without attaching blade. When I attaching the blade its not moving. Can you help me to solve it???
Can we make Philips trimmer from DC to AC?
bhai is ki sply main kitne hom ki resistans hoti hai please btao
Super ji Thank u
Thank you so much dear ❤️
Is there same procedure for 2 aaa batteries trimmer sir
amazing anna
Small connector between blades and rotating motors vo bahar aa jata h Jo round round ghumata h blade k lagane k baad aise bahut tight h
what is the the maximum voltage we could run a trimmer motor at, safely ?
2volt
@@ashokatech How much increasing the Volts is Safe to increase the speed ?
My trimmer is working but it's not charging. I tried with another charger also but it doesn't work. Help me?
aap is video ko dekhiye ruclips.net/video/QmJrnq0PCAA/видео.html
@@ashokatech hello
Super ji
Thank you so much
Very nice 👍
Hi Sir, please tell how to direct it, my battery does't charge so i want to use it with it's charger only.
I want same ...
But how
I changed the battery and now the weight that moves the blade loses traction with the motor. Motor shaft is spinning inside the hole in the weight, and the weight doesnt move. What can be done about it?
UPD its probably not the best idea, but i followed advice from the comments and superglued the rotor to the motor shaft. Works fine. Just be ready to turn off the trimmer if the blade is stopped by thick hair or something, otherwise the motor can be damaged.
Sir can I get the motor shaft anywhere now?
Hi how can I make it to run directly on charger.
Hi sir. I have this kind of trimmer.
I can use it, when it fully charged 100%.
Let’s say I used it for 5mins and the battery still have 80% remaining at that moment.
If I’m no longer use it, it will automatically drained to 0%.
So everytime I want to use it, i have to charge all over again.
What is the problem?
Shouldering machine nhi hai, kuch alternate way hai ?
Trimmer length adjustment kam nahi kar raha hai ... thik ho sakta hai kya? Length adjuster ta rotate ho raha hai par up down nahi ho raha hai.
Bro ,i have changed the battery ,put infinite 1.2 v 1050 mah .but now trimmers seems drop in power or rpm drop .what a reason ,i also charged for 7 hrs
Thank you 👍
Your welcome Sir.
@@ashokatech sir... Meraaa Trimmer ka motor move kar raha hai... bt jab blade se laga ta hu to motor didn't work what should I do????
Aur yadi mujhe motor change karna hai to uska Serial no or anything ????