Low mileage F150 with sun roof problems? 🤔
HTML-код
- Опубликовано: 5 сен 2019
- hopefully this helps anyone with a F-150 or f250 with a panoramic sunroof. noticed it wouldn't open, quick investigation seems to have found a solution. comment below! thanks for watching!
I was having issues with mine, and what I found is that the rubber gasket that runs along the outside of the glass up against the roof panel will dry up over time, get covered in gunk, and start to almost bond to the roof. Which makes the moomroof not work properly. The solution is super easy and very cheap, so no need to pay almost a grand at the dealership to have someone "fix" it. With a wet microfiber cloth scrub ALL the gasket, front back and sides, as well as the parts of the roof panel that it meets. Use rubber conditioner in all the gasket, and use a silicone based lubricant on all meeting surfaces, including the roof pieces that meet the gasket. And boom. Good as new. Just do this once or twice a year and you're good 👍
common issue with the Ford sunroof, the tracks are made of plastic and continue to break. I've replaced my King Ranch sunroof twice and rails are broken again. Seems like FORD should rectify and recall the tracks, Especially since these trucks are very expensive!
How much does it cost to repair broken tracks? Mine just broke 20 minutes ago 🥲
@@malghawazi up to 2400
@@GorefeastDrummer Yea if you're dumb enough to take it to the dealer and have some kid right out of high school work on it. But you can buy just the tracks online for around 150 bucks and about an hour of your time to change them out lol Mine have been broken for years on my 2017 f250 but still works. I just reset the tracks once in a while and unscrew the glass and clean the tracks and reapply kryton grease and it still works even though they are all busted up and cracked and broken in multiple places. It's honestly just typical pos ford saving few cents on cheep parts. Same as the mustangs with the china made mt-82's. Ford doesn't care about you or the American people and just care about the $$$ and they know you all will keep on buying ford and ford knows it and make their vehicles cheaper and cheaper every year. Most new fords "well pretty much all new fords" now have plastic oil pans and trans pans. If that alone doesn't scream cheep I don't know what does.
Just happened to me for the first time..came on RUclips,glad I’m not the only one...now it works!! Thanks again
Don't worry. It will break again.
Thank you. Mine was stuck and your video helped me get it unstuck. Will never use it again.
This happened on my 2018 F150 last week. Took it to the dealer and they quoted $900 to replace parts. I paid the $90 diagnostic fee only to give me time to try your suggestion first. It worked! Thank you for taking the time to post this video. You saved me $800 and change. Thanks!
You just going to leave it closed for a while?
Had the same issue roof wouldn't close. Was still under my CPO warranty but the dealership had my truck for almost 2 mths and they didn't seem to have a clue for the first 1.5 mths. Finally got it fixed and like you now every time I use it I always open in the vent first then close and open the roof. Gotta admit I cross my fingers everytime I open the it. Clean and lube the track often and check the seals.
I love you soo much man. Borrowed my bosses car today and same thing happened and you saved me. For anyone else looking for help Google search F-150 sunroof factory reset and that helped close it when I got it completely open.
Turn on turn on turn on turn on turn on, click close button, let go, then hold close button and should work. Good luck boys
* turn on position, turn off, turn on position, turn off, leave in on position (not completely on) follow steps above. Made typos
Thanks brother... good info. Did the same thing myself. It worked... but still a little worried.. we'll see. Thanks again.
Just happened to me yesterday. I’m so mad. Then I see ur video. Now I’m less mad.
So I “fixed” mine. First, I used a small LEGO sword to go around the seal from the top. That got me to vent up. Then I got to full open. Cleaned the railways for the window of debris. Found little pieces of plastic from something broken but I don’t know what. Then, it wouldn’t close all the way. That kinda told me it was a sensor or something. So 15 minutes of looking and trying different things, in the end, I just gave it some help as it was closing and it closed all the way. Now it is functioning normally, but I don’t trust it.
@@jsanchezelonce3414 lol a lego sword
I'd apply some RV rubber seal conditioner (either 3-in-1 or Camco make a good one)
appreciate this video. saved me hundreds from taking it to the dealership.
My truck has 74,000 miles this just started and after a rain it started leaking so make sure it closed all the way. Thanks fr for posting
This just fixed my sunroof! Thank you!
Get factory lube.
Mine stayed stuck too and I couldn’t get it into the vent, open or close. I pushed and held the “close” and “vent” buttons at the same time and that worked! Not sure why but it’s back to normal. Now I’m afraid to ever open it again. Thanks for posting!
Maybe leave it shut😬
This is why I didn’t get my f150 with a sunroof. I purchased mine and plan on keeping it for a long time so I knew it would eventually leak or have issues. Plus, we rarely use the sunroof in all our previous vehicles. It’s too hot here in Florida.
I had an Edge with the vista roof and it was great. No issues
Bro!? I wish I could buy you a Beer.
I had the exact same problem and did exactly as you did.
Worked like a Charm....
Thank You
Thanks for watching!
Since im Swedish i dont know if this is the correct word for it. But i would recommend you to lube?? the seal with a siliconebased spray like wd-40 silicone spray. Make sure you dont use a spray cointaining any petroleumbased contents (petroleumbased will make the rubber seal stick even worse and later on crack).
I would also recommend you to clean the rails that the sunroof slides on. Q-tip and toothbrush should do the trick cleaning all tight spaces. And then relube the rails with lithium grease!
Now your sunroof should open like brand new and also be protected against leaks even when in cold climate!
Im gonna take a look at the rest of your videos now!
Lycka till!!
Very good advice! Thanks a lot!
This is exactly correct. I had the exact same issue on my 2017 F150. My sunroof broke 3 times. Come to find out the seal kept sticking in the center due to the Texas heat. I lubed it with WD-40 and haven’t had a problem since
Mine cost me $2,500 on my 2016 F-150 just after the warranty ran out. The parts inside are plastic. If the cable breaks you have to buy the entire unit and two new motors. I had complained about it sticking to the dealership for 1.5 years, but it didn't fail completely until after the warranty ran. The deal is that the seals stick and stress the parts (many are plastic). If you lubricate the seals on a regular basis with a silicon lubricant, it seems to solve this problem. Ford should do something about this. I got hosed.
So did mine. Sunroofs from Ford are crap.
Any updates? Grease the rail? Nice color btw. Is that the Caribou Green, such a nice paint
Clean with alcohol, mine was doing the same thing. I did exactly what you did, vent the roof first then open. Works every time, I do have a smell but can not find any leaks
Pray these parts are made better
Wow I thought my f150 had this problem, looks like I’m not the only one. Built Ford Tough I guess lol I love my truck tho
That's annoying. Although that's just a symptom of sunroofs like that these days. There is only one I've seen without it and that was on my mom's '87 Nova but that literally vented up and went back down. No sliding. I do like the idea of the airflow and the cool view some days, but I don't think it's necessary and I do know the ones without it are actually quieter on highways.
This seems to be a pretty common problem, despite the dealership claiming they don’t hear many complaints. I have a 17’ F150 with a panoramic sunroof and I have the same problem. Goes up to vent but won’t drop down to open.
Did you ever find a fix?
Da Vert yeah, I ended up putting some dielectric grease on the seals and it dropped right down. Only problem is, the plastic track piece was broken so the glass made grinding/crunching sounds when I rolled it back. I have the new plastic parts ordered which were about $150 and I found a RUclips video on how to replace them so I’m just gonna do that. The dealership and ford won’t do a thing for you if you’re outside of your bumper to bumper warranty 😑
MLongPhotography alright thank you!
My 2017 F-150 just started the same thing a few days ago.
Put krytox around the seals it’s what ford uses. I have had no issues and rarely open my moonroof but when i did it no longer sticks and runs smooth.
Thank u
Always always always vent your sunroof before you attempt to fully open it
Why
seal sticking to paint and cause the jam. good you fixed it. panoroofs fail when not cleaned, maintained, lubed. they squeek, rattle, crack and break then can be costly to repair depending on what breaks.
What's the best product to move the seals?
Sorry you had the problem. I would let it set a couple of days without opening it to see if it will stick again and if so I’d go direct to my dealers service dept to get it documented.
Ive had that exact issue from when i first bought it in 2017 and its still like that 2024 lol
I have a 2015 Platinum F150 which has had the sunroof break 4 times. Exact same issue. The seal seams stuck and the track breaks on me. I have to hit the vent button first. If I forget to hit the vent button and hit the open button, it breaks the tracks. This week after 2 years of remembering to hit the vent button, I forgot and hit the open button. Sure as poop it broke. And now that it's out of warranty the dealer is saying 10 hours of labor to repair and $3500. Facepalm. I think we need to start up a class action on the issue because it's clearly a design issue. The dealer has blamed trees around my house. I have spent 15k cutting down trees. There are absolutely no trees over the truck where it's parked. This is crazy.
Sorry that happened 2 u
Please add me to this class action suit! I’m MAJORLY MAD!
This is insane. My dealer fixed mine for $600
I'm considering having my sunroof closed up and not with aluminum and rivets. I want steel to be welded in. Because you know its gonna break again...I detest cheap plastic parts. And if I use aluminum, it will flex, I thought about doing a race type roof that flips up, but that will leak most likely...
I had the same problem on my 2016 leased F150, The problem started at the end of my lease I kept it closed I returned the truck and. Now I have a 2019 I'm sorry you had those problems too. Hopefully with my new truck I won't experienced those problems with the sunroom. Still a nice truck though
Any issues? Local dealership in TX has a few new 2019 5.0 for sale with the sunroof... it'd be cool to have one (being that it doesn't fail)
@@damianlopez6583 I'm good i love my 2019 No issues yet I hope I don't experience any problems with this new truck,
One feature on a truck I would not want, I pray the one on my wife’s Mkc doesn’t act up 😬
which screw will you loosen?
I have the same problem with my 2018 expedition.
So I'm getting the exact same thing but it doesn't go into the vent position or open.. I've tried many things and nothing works
2018 F-150 lariat moonroof has the exact same problem. Just took mine to the dealership. Seems like a common problem. I'll update once it's done.
Any update? I have a 2019 doing this and was hoping to clean and lube the seals. But if thats not the fix, then might just take it in.
Seals and metal need periodic lubrication clean with alcohol then use some type of light grease around same surfaces
Get some silicone paste and put on the edge of the seals/window every couple months.
Here is what is wrong. Or was, if you've fixed it since
ruclips.net/video/wqeCjLI6mrc/видео.html
What was sticking it is a broken piece of the lift arms that has fallen down into the track. If you have not done that repair, I would highly advise you not use it until you do. I have other videos on how to lube it, program it, etc.
Also, and this is very important: Every couple of months, vent the window. Wipe off the rear of the seal (on the front glass that is vented) with a wet paper towel or old rag. Then lube it. I use 3M Silicone Paste. Got a video for that, too.
Then: Whenever you open it...ALWAYS vent it first. That will overcome any "sticking" that might have occurred between the two glasses, and venting it is much less strain on the lift arms than trying to pull it down and retract. So vent it first, then you can open it.
Awesome! Thank you!
The dealer might know what the problem is if they have seen this before? I think you are right about the seal though. It looked kinda messed up as if it got sticky and then stuck. I just wouldn't want your sunroof to go kaput after the warranty is over. Let us know if it happens again.
Will do, thanks for commenting!
Have the some problem on my 2018 King Ranch F150. All I did was push from the outside a little bit and it started going back like it should. Not sure if this affects it or anything but it worked
Interesting
just bought a 2017 F-150 Platinum 2 days ago, and this exact same thing is happening.
Dude I had the same problem with my 2018 only when mine opened it went all the way back and broke every plastic piece. Took it to the dealership and thankfully I had bought the extra warranty because it was a 3000.00 replacement! But now it has some sort of issue with closing, it’s sensitivity is some touchy that when it touches the air foil it thinks there’s something in the opening and it reopens. I have to hold the close button down to get it to shut.
Same 🤔
Dealership just charged me $600 to replace rails. The extended warranty I paid $3,695 for only covers the motor. Didn't even leave dealer, hit the close and the rubber boots crumpled and jammed the sunroof. I'm NEVER getting the sunroof again. It's obviously poorly designed and should be a recall. I'm going to contact a Class Action lawyer and Ford needs to compensate for these repairs.
It should be. If it doesn't close and water is getting into the vehicle it's a huge safety hazard.
Same thing just happend to me 27k miles still stuck
YES!! This is ridiculous. We are ALL having this problem! I started having water leak through the front grab handles on both sides right after the warranty expired. Very disturbing when you!re driving down the road. Recall or lawsuit. I’ll be checking my mailbox.
Hold on.. found this "2015-18 F-150-350 Sunroof Initialization" on YT. That actually got it open again!! Will see how long it lasts.
This is why I like my 2018 f150 stx no extra shit that can break. Its 4x4 locking differential 8in infotainment system is the most technology it has. I wad just going get the regular xl 4x4 supercab,but the stx was a great option. I like a work truck not a cowboy Cadillac. I do like your truck though. My wife has a 2018 explorer platinum. She got the nicer car and I got a good work truck.
the explorer platinum is NICE!
@@DS-TRUCKS thanks! Once her lease is up in February 2020 she wants to lease the new 2020 explorer.
@@leeaguilar6126 🤔 that will be nice!
Spray the seal and the sunroof rubber with silicone.
Some people are just not bright.
So what did you do to pop it up? Explain how you were able to get the vent position open.
Idk... I just pressed the vent button. Yours must really be stuck...
The problem is a bad design of the tracks. Ford did a redesign. I had my tracks/rails replaced with the redesign.
So I found some brand new 2019 at a dealership here in TX. A few of them have the sunroof/moonroof. Think I'll be okay to buy one? Is it considered bumper to bumper warranty (hopefully it doesn't break) right?
Damian Lopez should certainly be covered under warranty. I’d do research on Ford F-150 forums to see if there is information when the redesign was rolled into new vehicles. Alternatively just insist the dealer replace the tracks on the sunroof and be done
@@freel213 The arms had a slight change in them roughly a year ago. Fall 2019 is when I saw the first updated set, and I install more than probably anyone.
I just did a set on a 2019 yesterday, so they still break unfortunately.
5k miles on my new super duty, been doing this for the last 2k and ford has my nearly $100k and the government has the other $100k I earned to buy this truck. My sunroof is bad, backup sensors, door rattles, alignment was bad on day one.
My man in the bucket hat like LL COOL J. No such thing as a bullet proof sunroof, they all have problems.
Lol. I haven't appeared on the channel on the while!
Mine doesn't even open up!
Drivers side is fine. Loosen the screws on the passenger side and tap the glass up to match the Drivers side.
Same issue here but do u think the sealing had been damaged because it was stuck? Because any smell in the atmosphere i can smell it even though the the AIR CIRCULATION is ON. There is no problem with the AC at all. Do u think it has something with the panoramic sun roof sealing!?
Idk
Recirc doesn't totally shut off air from outside, so you'll still smell things.
My window is stuck in the exact same position. How did you get it into the vent position?
Yeah cause I can't get mine in either? It just makes a noise and that's all.. Any suggestions? Other than don't buy a truck with a sunroof bullshit!
Mine stayed stuck too and I couldn’t get it into the vent, open or close. I pushed and held the “close” and “vent” buttons at the same time and that worked! Not sure why but it’s back to normal. Now I’m afraid to ever open it again.
I found a fix for my 19 raptor. Ordered it without a sunroof.
Smart
If you're using the Raptor in a manner in which it is meant to be used, I've heard of sunroofs shattering due to flex in the body in off-road scenarios
LOL
Hahaa
I had one in my f150. Broke twice.
Same thing my 2015 does. It will vent fine but if I try to drop down it binds up just like that. I guess I’ll give it a good wipe down with some wd-40.
Lube the system, and use a lube on those seals.
It's not the seals. It's the plastic railing. Mine have broken. 2016
Thanks! It needs to go into the shop...
I’m planing on ordering a 2022. I wonder if they have fixed it yet, or if it will still have the same issue?
it will last if maintained.
@@DS-TRUCKS ok cool I will make sure to clan it and grease it 👍
@@AJ-rg3pr Yes. They are products that are specifically made for sunroof
@@DS-TRUCKS oh ok great
Lube the seal all around once you get it open Dupont krytox gpl205 $$$ but worth it.
Never mind... broke again even after the lube! C'mon Ford.. get your act together.
I have a 2015 Edge AND a 2018 F150. BOTH of them have this very SAME problem. PLEASE tell me what to do. I took my Edge into a local dealer and they ABSOLUTELY RUINED the ENTIRE interior of my vehicle AND put some kind of “made up” shade in it. They left GREASY BLACK FINGERPRINTS EVERYWHERE! (It’s still that way)! That issue started at the end of bumper to bumper warranty. My F150 is doing the SAME exact thing now... i have NOT taken it to them because I’m still pissed about how they RUINED my other vehicle.
PLEASE ADVISE ME!
Where do you live?
My F150 sunroof did the same thing but no one was able to get it to work. It costed me $4,000 to put an entire new sunroof in the vehicle. Shortly after that I got water in my left rear tail light and they wanted $800 for that because it has the sensors. My doors started to make creaking noises when driving down the road and hitting bumps. My steering started to pull to the left and had front end issues.
Did you try this first? 😬 Sorry you had so many issues with your truck... Did you get rid of it?
Ahh this is why fords in a law suit
Gotta keep those rubber seals lubed up or they will stick together and break the track components .
What do you use?
DS TRUCKS I just use seal lubricant from pep boys, but any kind of silicone lubricant compound will work . I think Ford sells some for this application .
Another good tip is to push up on the glass with two fingers to assist the motor when putting into vent mode
I don’t like sunroof on a pickup. IMHO
I like em... Just wish they didnt break!
Any issues with it leaking
No leaks
My sunroof on 2019 F150 exploded while driving took me 3 weeks of fighting with Ford to replace it on warranty
This is due to any defect in the tempering process, it is unnoticeable. It can vary with temperature and humidity with each day. I work with these F-150 sunroof panels and have seen them explode upon touching them. Very startling indeed.
What do you mean "exploded" 🤔 like it shattered
Damian Lopez like bubbled up and shattered with loud bang while driving
Yes mine will go into vent but will not open will not buy another Ford
If it's still under warranty, take it to the dealership and get it fixed, it won't even cost you anything.
That's what I ened up doing... I had loaner coverage... But didn't guarantee I'd be in another F-150.
@@DS-TRUCKS I drive a brand new Volvo XC60 SUV and am currently in a Corolla loaner lol, so I feel ya. Still thankful to have a way to and from work and not be stuck with a rental bill though.
Clean everything with a degreaser then apply plastic safe lube on the edges and the seal and rails and you will never have a problem
Very interesting... You have experience with these trucks?
@@DS-TRUCKS I have a 2018 xlt sport 5.0 with everything you can get in it including the sunroof
Yeah, you don't have to do all that. Keep the seal between the glasses lubed...where they touch each other. That's the sticking point, and it puts enormous strain on the lift arms to break that seal.
And always vent the glass first, before opening it. That breaks the seal and saves the lift arms, which is what was broken on this truck. (and all the rest of them)
Clean and lube the back of the seal on the front glass, and it'll last much longer. But will still eventually break, just not as soon.
Pacfanweb knows his shit. Listen to him. :)
They sure don’t build trucks like they used to 20 years ago what a shame!
20 years ago trucks didn't have all this technology.
Sean, here’s my two cents for what it’s worth. Lube the seals real well with silicone. Close the sunroof, pull the fuse so you don’t accidentally open it again. Hopefully when you sell or trade the truck it will still work.
Yea... Not a bad idea.
Get some see throough gorilla tape, similar and when it's completely shut then tape around the outer edge and the middle where the roof splits. Shouldn't be able to see the tape and it'l completely waterproof any cracks. Swap the tape out every so often and there you go. I'd love to see someone manufacture a single panel piece of glass that can be mounted instead of the split glass. Te glass is nie to have i guess but who really opens it that much?
Hey FORD - notice 40 THOUSAND VIEWS and do something.
its out of square....BONDO THE FUCKIN THING OVER...MOONROOFS ALWAYS END UP LEAKING OR OTHER PROBLEMS