Hi i own a Karizma ZMR since 2012.Here are some tips and replacement part costs which will make your life easier.Brake pads front and rear( for rear bosch rs 300-350 per set).At front u may use bosch or tvs apache rtr 160 brake pads(rs 280-300).Karizma zmr/karizma one set front plus one set rear =1200+1200+400 labour at showroom, if u do it u r self using bosch and tvs total cost us rs 600 insted od 2800...its been 10months since i changed my pads( i drive 40km everyday approx ,6 days a week) still 60% thickness is present front and back ,that means in one yr i have driven almost 12,000km and still more that half pads remain..for clutch plates you can go for bajaj discover 150 set of friction plates(rs 650) and local mech can change for for rs 200-300 front of your eyes.Clutcg plate replacement at showroom will cost you rs 2500-3000 parts and labour, but bajaj friction set and labout cost at local garage will only cost you 900 rs.The best oil for karizma zmr is shell ultra 10w40 fully synth .U can change it once in 5k kms and it will give u smooth engine,smooth gear shift,cool engine and performance.If u dont use fully synth and plan on putting fully synth make sure u do engine flush before putting fully synth oil .Only add 1.1 liters oil even though manual mentions 1.35 liters(arround 150- 200 ml is always present in engine even after u drain old oil,so only fill 1.1 liters.How to check oil capacity- put the bike at center stand,start and idle engine for 3 min,off it and immediately open the oil dip ,clean it with a clean cloth and put it back(do not screw it in) and the level should next to the higher mark.If oil is low after filling,only add 50 ml at a time and check(do not overfill oil).Always when u start bike,idle the bike for 20 sec at neutral(do not use accelerator) ,this will ensure good engine lubrication before bike moves and minimises friction,wear and tear.Always clean carburator once in 10,000 kms.If its an old bike,u can put new cam chain,cam guide ,cam sproket and cam chain tensioner( kit of 4 parts comes for rs 1400).If theres no problem,atleast put new cam chain tensioner(rs 421) and old bikes cam chain tensioner becomes loose,replacing a new one will ensure good cam chain tension.Adjust tappet clearence and clean air filter,if u can replace it as new one costs only rs 240.Always lubricate clutch cable by putting some oil in it using a syringe and fresh engine oil(believe me ,if u lubricate once a month, u r shifts will be like butter).Adjust bike chain slack and use a thicker gear oil(75w90) for chain lubrication rather than chain spray as is more thicker it will lubricate and protect chains for longer duration from rust( u get gulf pride gear oil rs 169 for 500ml).Clean battery terminal abd put some vasaline jelly for smooth charging,conduction and antirust/dirt.The exposed exhaust from head to silencer gets rust easily,so use sandpaper,sand that area and spray paint with high temp rest.paint,also after painting u can wrap it with silencer tube wrapper from the engine gead til lstart of the silencer,so heat dosent effect your right foot or engine.Once in 6 month clean and lubricate throttle cable using wd40.If u want better lighs u can put philips xtreme 150 halogen bulb(rs 350-500),its prettly good compared to stock or hid if u got money to spend.Any karizma,karizma zmr parts can be purchased online at thesparescompany.com or safexbikes.In kochi kerala,near SA road there is Focuzbiwheelers workshop,after entering service area,if u go behind towards left side,u have a huge wharehouse and spares area where u can buy almost anything for karizma from body parts to timing chain to tank to air filter,nuts and bolts,mirrors,silencer gard,handle,levers,throttle cable,acc cable,seals,u name it,they have it and you can but them.Lastly for best performace and mileage,drive between 45-55 km /5th gear.If u plan to use normal oil,change it at 2K, if semi synth change at 3K and Fully synth change at 5K.Avoid hard and fast acceleration and for carbertor,set idle rpm at 1200(4 -5 bars).Shift gears between 3000-4000rpm.Everyday for 5 min in morning or evening wipe the entire bike with dry microfiber cloth so that u r bike is always new and u just need to water wash once a month.Use a good wax after wash to protect paint and to give it shine.Always park at shade( lesser petrol evaporation and paint does not fade) Buy a tank cover/ protector.Fill tyres with nitrogen front ,29 psi,rear 31psi and check n2 level once in 2 weeks.Dont frequently wash bike(only once or max twice a week).Use platinum or iridium spark plugs for better performance and mileage. Ride saftely.At present stay home stay safe.Whatever i said applies for both karizma and karizma zmr
Hi i own a Karizma ZMR since 2012.Here are some tips and replacement part costs which will make your life easier.Brake pads front and rear( for rear bosch rs 300-350 per set).At front u may use bosch or tvs apache rtr 160 brake pads(rs 280-300).Karizma zmr/karizma one set front plus one set rear =1200+1200+400 labour at showroom, if u do it u r self using bosch and tvs total cost us rs 600 insted od 2800...its been 10months since i changed my pads( i drive 40km everyday approx ,6 days a week) still 60% thickness is present front and back ,that means in one yr i have driven almost 12,000km and still more that half pads remain..for clutch plates you can go for bajaj discover 150 set of friction plates(rs 650) and local mech can change for for rs 200-300 front of your eyes.Clutcg plate replacement at showroom will cost you rs 2500-3000 parts and labour, but bajaj friction set and labout cost at local garage will only cost you 900 rs.The best oil for karizma zmr is shell ultra 10w40 fully synth .U can change it once in 5k kms and it will give u smooth engine,smooth gear shift,cool engine and performance.If u dont use fully synth and plan on putting fully synth make sure u do engine flush before putting fully synth oil .Only add 1.1 liters oil even though manual mentions 1.35 liters(arround 150- 200 ml is always present in engine even after u drain old oil,so only fill 1.1 liters.How to check oil capacity- put the bike at center stand,start and idle engine for 3 min,off it and immediately open the oil dip ,clean it with a clean cloth and put it back(do not screw it in) and the level should next to the higher mark.If oil is low after filling,only add 50 ml at a time and check(do not overfill oil).Always when u start bike,idle the bike for 20 sec at neutral(do not use accelerator) ,this will ensure good engine lubrication before bike moves and minimises friction,wear and tear.Always clean carburator once in 10,000 kms.If its an old bike,u can put new cam chain,cam guide ,cam sproket and cam chain tensioner( kit of 4 parts comes for rs 1400).If theres no problem,atleast put new cam chain tensioner(rs 421) and old bikes cam chain tensioner becomes loose,replacing a new one will ensure good cam chain tension.Adjust tappet clearence and clean air filter,if u can replace it as new one costs only rs 240.Always lubricate clutch cable by putting some oil in it using a syringe and fresh engine oil(believe me ,if u lubricate once a month, u r shifts will be like butter).Adjust bike chain slack and use a thicker gear oil(75w90) for chain lubrication rather than chain spray as is more thicker it will lubricate and protect chains for longer duration from rust( u get gulf pride gear oil rs 169 for 500ml).Clean battery terminal abd put some vasaline jelly for smooth charging,conduction and antirust/dirt.The exposed exhaust from head to silencer gets rust easily,so use sandpaper,sand that area and spray paint with high temp rest.paint,also after painting u can wrap it with silencer tube wrapper from the engine gead til lstart of the silencer,so heat dosent effect your right foot or engine.Once in 6 month clean and lubricate throttle cable using wd40.If u want better lighs u can put philips xtreme 150 halogen bulb(rs 350-500),its prettly good compared to stock or hid if u got money to spend.Any karizma,karizma zmr parts can be purchased online at thesparescompany.com or safexbikes.In kochi kerala,near SA road there is Focuzbiwheelers workshop,after entering service area,if u go behind towards left side,u have a huge wharehouse and spares area where u can buy almost anything for karizma from body parts to timing chain to tank to air filter,nuts and bolts,mirrors,silencer gard,handle,levers,throttle cable,acc cable,seals,u name it,they have it and you can but them.Lastly for best performace and mileage,drive between 45-55 km /5th gear.If u plan to use normal oil,change it at 2K, if semi synth change at 3K and Fully synth change at 5K.Avoid hard and fast acceleration and for carbertor,set idle rpm at 1200(4 -5 bars).Shift gears between 3000-4000rpm.Everyday for 5 min in morning or evening wipe the entire bike with dry microfiber cloth so that u r bike is always new and u just need to water wash once a month.Use a good wax after wash to protect paint and to give it shine.Always park at shade( lesser petrol evaporation and paint does not fade) Buy a tank cover/ protector.Fill tyres with nitrogen front ,29 psi,rear 31psi and check n2 level once in 2 weeks.Dont frequently wash bike(only once or max twice a week).Use platinum or iridium spark plugs for better performance and mileage. Ride saftely.At present stay home stay safe.Whatever i said applies for both karizma and karizma zmr
Very good writing bro😍
Lovely bro mostly half the information u provided is followed by me since 2015.. robust engine karizma.
Thankyou
Bro karizma ril rear disc brake fit Chaytha oru vedio idana bro corona kayinjit Mathi
Bro super kure kalayi search cheyunnu 2013 muthal..santhosham
Most waited video 😍
Rear ഡിസ്ക് ഉള്ള hunk, cbz, dazzler, zmr ഇ ബൈക്കുകളിലെ റിയർ ഡിസ്ക് സെറ്റ് karizma r ലേക്ക് ഡയറക്ട് ആയിട്ട് സ്യൂട്ടാവും
Much awaited video
🥰
make some video on tail light fitting. other wise tell me any other modification need to fit zmr tail light to karizma r.
bro ith evidelum cheythu tharunna workshop undo
Hi bro xpulse nte fork set ketiyal enthelum issues varumo??? Ball raiser tstemp nte bagath ninn ellam...please reply im planning to do so..
Cbz rear disc break set direct fit in Karizma r
Hi bro tell me about front suspension how did you increase it height
Bro zmr inte foot peg stay r lum direct fit ano
Bro saddle custom cheythath ano
Enna rate ayi
Bro njn zmr il Rnte kit ketty.. tank eke same ane.. engine guard vekkan cherya 2 clamb mayhre avisham vannat ull
Aa, ariyam bro
R inta kit nth rate und?
@@zeenvlogs5851 i think its abt3500,
Bro kittinte clamp matano
@@salmanjerry4v382 clamb matanda Rnte meter stay venam.. meter consol koode Rnte akiyal perfect
Pwolii pwolii pwolii.......
❤️karizma
You are always best
Which company brake pads ??
Bro disc itt kayinjal brakeing engane ond
Eganeya as 200 windshield karizma r il fit cheyyuka..
Radiator is working or not? bro...
Rear disc brake cheythath eth workshopila? Bro thrissur aano?
Thanks brother for the video
Thanks for watching ,🥰
Xpulse bs4 oil cooler set akan kazhio
Nice bro.. Rear disc add cheyyan ethre cost akkum ( exact cost) .. Bro fresh parts aon medichathu???
10 k de ullil , njan cheythapol 12 k + aayi
@@wander6 phone number
Good info bro.
Windshield etha anu install cheythathu. AS200 inde ano?
Bro dazzler wheel width ethra pinne zmr swingarm enthelm chytho
Radiator xpulse l install cheyyan patto
Ee setup patilla, bs6 il varunundel ath cheyyan patum
Bro ee hero hunk suite aya ethelum better break caliper undo
Hunk nu optional disc varunundallo athinte spares vangiyal mathi
@@wander6 bro front break anu change cheyyande break nalla soft anu
@@ananthnath8730 master cylinder maatiyal mathiyaavum cbr 150 , apache rtr okke suit aavum, cbr 150 de aanel mirror fit cheyyanathe il koduth thread cut chryyendi varum
@@wander6 okay thanks bro
Bro milage 45 kittumo
Polichu bro
Nice bro 🔥🔥👍
Thaanku
can ZMR back disc can be used into Karizma R back
Yes
200nsil offroad povan nthokke setup cheyyanam?
Prathyekich onum cheyyanam nu illa bro, position onude set aavanel handle bar single piece aakiyal nanavum
@@wander6 yes bro enikyum atha thonune ah riding poisture aanu korch scn...
btw njan RD de handle bar nsil ittal vela probs indo njn ithuvare aarum angane nsil keti kandilla atha choichey
Bro nte karizmak nalla self prblm nd sheriyakiyalm korch kzhnjaa pnee kedu verum
Bro karizma R il wheels size increase chyan ethelum vazhi undo???max120 alle
110 anu max
Pakshe 17 inch alloys install cheythal 130 vare pokum
Njan 18inchil 120ittittind, 130 idaam but ath round aayi nikkulu, width thonilla, wheel nu width illaathond
@@jobinchacko9749 apo etha vandide alloy aanu use cheya
Kicker enthiana vendanne vekkumnee
Hello
Oru karyam ariyanund mashe !
Karizma Ril ZMRinte digital console vekkamo ??
Ariyanula thalparyam kondaa
@wander _6 reply please
Full settings kittanamenkil
Any way
Macahne back disc cheyyan cash aakum
can you make a video in Hindi or English pleaseeeeeeeeee
Bro vere radiator vekkan pattumo zmril ?
Ente vandi Karizma r morning start aavum Ilya, enthelum nalla workshop suggest cheyamo?
tank opencheyth air e daily morning kalayanam then chok itt self adikkuka
Choke ഇട്ട് start ചെയ്താല്മതി tank തുറക്കേണ്ട koode key onn off cheyth on ആക്കിയമത്തി
Please make this video in English or Hindi
Should be subtitles added bro
Bro rear discinu othiri cash aakumoo
Brilliant
E video enn idanam bhaaii
Eath?
👍👍👍
✌️😍😍
Hello
ബ്രോ കരിസമ r ഇപ്പൊ വാങ്ങിയാ പണി കിട്ടുമോ ples riply
Nop
Maintain cheytha madhi
@@mdshlvp spare കിട്ടുന്നുണ്ടോ
@@sbth9521 അവൈലബിൾ in wins കാലിക്കറ്റ്,,. കോയമ്പത്തൂർ etc
പിന്നെ loverne പോലെ ആണ്
അവള് ചോദിച്ചാൽ മേടിച് കൊടുക്കിലെ,,, അതെവിടെ ആണേലും ശെരി,,
ZMR REAR DISC 240MM HUNK&DAZZLER 220MM
Athinentha bro.? ,20mm difference illa randum thammil 10 ullu
bro vandi chumma nasippikkale maintain natural look
Sheri chetta 😅
hindi plz
Yep , it never will be about followers as your use of some obscure language will ensure it never reaches mainstream .
എന്തൊരു ബോർ video 😏😏😏😏😏😏😏😏 എടുത്തോണ്ട് പോടെ