RockShox Yari RC Fork Full Rebuild (200 Hour Damper and Spring Service)

In this video, we perform the full 200 hour damper and spring service on a 2018 RockShox Yari RC fork. With the exception of the damper service, this largely applies to the RockShox Lyrik as well.
SERVICE MANUAL:
www.sram.com/g...
TOOL LIST:
(Some links may be affiliate links. If you click them, I may get a small commission, no purchase necessary!)
RockShox Yari 200 Hr Service Kit: amzn.to/3UjOcdb
Isopropyl Alcohol: amzn.to/3WkN8s0
Metric hex wrench set: amzn.to/3xXwRiB
Rubber mallet: amzn.to/49YXLnF
Loctite 242: amzn.to/4biUujU
Maxima Plush Dynamic Lube (Heavy and Light needed): maximausa.com/...
RockShox 5wt Oil: amzn.to/3xWcWk1
SRAM Butter grease: amzn.to/4djLCMY
RockShox Bleed Syringe: amzn.to/4doj2tJ
RockShox 35 mm Dust Seal Installation Tool: amzn.to/4dw23WG
Shock pump: amzn.to/4aYbegT
Cassette tool: amzn.to/4b0oQbw
Downhill tire lever: amzn.to/3Qr4O1D
Park Tool AV-5: amzn.to/44rj7sz
Bench vise: amzn.to/3JHnia5
15 mm crowfoot socket: amzn.to/3UDdR1S
Flat blade screwdriver: amzn.to/3JIMQny
5 mm hex socket: amzn.to/4bmogoh
Retaining ring pliers: amzn.to/3QpJQzT
Needle nose pliers: amzn.to/3Qs3Hi9
15 mm wrench: amzn.to/44lC8N4
Pick: amzn.to/3y05zZ2
24 mm socket: amzn.to/44k1IlH
Socket wrench: amzn.to/44ueJcw
Torque wrench: amzn.to/3UpNn2z

[@Phreggdrick]

Just as a bit of info: If you have 2018 Yaris the service manual is a bit misleading about the need of heavy dynamic lube for the upper portion of the airspring and is not required for the Yari RC (at least for the 2018 version in the manual, I got confirmation of this by Rockshox directly) so don't panic if you don't have it and it could save you some money too! Also for those planning on doing your own service don't use too much butter grease between the upper and the air spring piston. If you do you can clog the equalisation dimple and you'll get bad fork suck down.
... Also Great Video!

[@marklouieadame]

best rebuild and service detailed simple and straight forward excellent editing

[@concordcycleworks]

Thanks! Be sure to subscribe for more!

[@ktom300]

Best rebuild video out there, nice work

[@concordcycleworks]

Thanks a lot! Be sure to subscribe for more!

[@masaru3585]

I don't get it (6:05), in every tutorial and even in RockShox Manual, they say 180ml 5wt. but I don't need even to put 150ml in and it already overfill. I have a Yari Compression 2022 :/

[@2Philthy]

I cant figure out what I did. Fork will run smooth and hold air through 1-3 rides. Then looses air after sitting and/or during ride. Pump it back up and holds for at least one ride (wvwn bike park) and then same. I took it back apart and checked seals, tightness, ect. Camt figure out where or why its losing air. So frustrating.

[@woals72]

thx a million!!

[@flaviomarzocchi7444]

Great job

[@IslandFilmMaker]

Well Done! I got it!!

[@angp4397]

Marito M 30 needs gas chamber oil? I mean the inflatable position

[@stevebennett3587]

👌proper service👍😉

[@concordcycleworks]

Thanks!

[@SurvivalSquirrel]

Jeeeez! I searched for half an hour to find someone doing 3:53 with the same problem, but then you heavily cut it out. Why would you??

[@concordcycleworks]

What problem at 3:53 are you referring to?

[@SurvivalSquirrel]

The amount of work/tricks it takes, to get this clip in! @@concordcycleworks

[@amielenriquez186]

Do u really have to chip off that plastic part to remove the circlip.

[@amielenriquez186]

Its a hard to remove and even harder to put back in

[@concordcycleworks]

You do not chip off the plastic, you depress the plate that the plastic part sits on so the circle can compress/be removed

[@RMFUNTIK]

maxima light and heavy are the same as 0w30?

[@concordcycleworks]

Yes, 0w-30 Suspension Oil can be used in place of both Maxima Light and Heavy

[@RMFUNTIK]

@@concordcycleworks so the entire fork 50/200 can be done with 0w30? But manual says there supposed to be different oils? Or it's just SRAM rebranding?

[@concordcycleworks]

The manual specifies 0w-30 can be used in place of both Maxima Light and Heavy

[@RMFUNTIK]

@@concordcycleworks this is a total mess from SRAM :) Im so confused about oils... Well can you please advise me, I have a rockshox zeb charger r, I need to do a 200h oil change, I can I use 0w30 in lower leg, air can, and charger ? Or I need different oils? Thank you!

[@D_i_c_t_a_t_o_r]

ЕСЛИ ВНИМАТЕЛЬНО ИЗУЧИТЬ ЗАКОНЫ СССР ТО ГОРБАЧЕВ НИКОГДА НЕБЫЛ ПРЕЗИДЕНТОМ,
ЛОЖ!!!